BACKGROUND: The veterinary Rabies vaccine was produced using BHK-21 cells and PV strain. Although various protocols have been suggested for virus purification, they have an adverse effect on the final production and require further optimization.OBJECTIVES: The present study aimed to optimize the concentration and purification of the virus for rabies vaccine production.METHODS: First of all, the Pasteur virus strain (PV) was cultured by using BHK 21 cells with DMEM media contain bovine fetal serum (7 %) for five days. Subsequently, the virus purification was done via tangential flow filtration (TFF) system. The quality of purifying viruses was an assessment with titration and SDS-PAGE. Secondly, the virus inactivation was optimized using Minitab software based on three factors, namely time, temperature, and concentration. Afterwards, the inactivity of the samples was tested on mice. Finally, the virus potency was evaluated by the National Institute of Health (NIH) method.RESULTS: The viral titration test in TFF samples revealed that viral titer increased in comparison with the control group (P<0.05). The SDS-PAGE analysis of the purified and concentrated samples showed that the purified virus via TFF had a higher purity compared to the not-concentrated samples. Moreover, the NIH test indicated a 10-fold increase in potency result in the TFF group.CONCLUSIONS: The present study implied that the TFF method is highly suitable for condensation and purification of a high volume of viral fluid and could be applied on an industrial scale to increase the potency of the vaccine produced.

Bovine fibroblast interferon (BoF-IFN), produced in primary bovine embryonic kidney cell cultures after priming and infection with bluetongue virus, was purified by controlled pore glass (CPG) chromatography to a specific activity of 10(6) U/mg of protein, with 40% recovery of the original activity. The crude IFN was concentrated more than sevenfold during purification. This proved to be a relatively simple, practical method of obtaining sufficient quantities of partially purified natural BoF-IFN for further studies. The CPG-purified BoF-IFN was further concentrated by sequential ultrafiltration and was analyzed by sodium dodecyl sulfate/polyacrylamide-gel electrophoresis (SDS-PAGE). Interferon, recovered from denaturing conditions either by dialysis against phosphate-buffered saline solution or by dilution in cell culture medium containing 10% fetal bovine serum, migrated as a single stainable protein with molecular weight of 21,000 on analytic SDS-PAGE gels. Recovered IFN activity from preparative SDS-PAGE totalled 8.7% of that applied. Attempts to further purify CPG-purified BoF-IFN by zinc chelate affinity chromatography were unsuccessful.

Fifty serum samples from dogs with clinical signs of hypothyroidism and autoantibodies (AA) to thyroglobulin (Tg), thyroxine, or triiodothyronine were screened for AA to thyroid peroxidase (TPO). Thyroid peroxidase is the antigen against which microsomal AA are formed in human beings with lymphocytic thyroiditis. The TPO was isolated from canine thyroid tissue, using a modification of the procedure for purifying porcine TPO. The enzyme was solubilized from the membrane, using a deoxycholate-trypsin solution, followed by ammonium sulfate precipitation and diethylaminoethyl Sephadex chromatography. Activity of TPO was determined, using an iodide oxidation assay and a guaiacol assay. A monoclonal antibody to canine Tg, coupled to an immunoaffinity column, was used to eliminate the contaminating Tg from the TPO preparation. Using the TPO preparation as an antigen, an ELISA was performed on 10 serum samples and immunoblot assays were performed on 50 canine sera. Autoantibodies to TPO were not found in any of the sera. Assays also were performed, using purified porcine and human TPO and evidence of cross-reactivity with canine TPO was not identified. The absence of AA to TPO in dogs suggests a different pathogenesis for autoimmune thyroid disease in dogs than that hypothesized for lymphocytic thyroiditis in human beings.

Objectives of this investigation were to extract and isolate protein fractions inhibitory to the cytotoxic properties of tumor necrosis factor-alpha (TNF-alpha). In this context, mixed populations of WBC were harvested from equine blood and were stimulated with a combination of a synthetic chemotactic peptide and a calcium ionophore. Several methods were subsequently applied for the initial preparation of cell-free crude protein extracts, including fractional precipitation with gradient concentrations of ammonium sulfate and preparative-scale isoelectric focusing. In addition, protein fractions were harvested from extracts of concentrated equine urine. Protein extracts of urinary origin were further separated by gel-filtration column chromatography. Identification of protein fractions possessing properties inhibitory to the cytotoxic characteristics of TNF-alpha was facilitated by a tissue culture-based technique for the biological assay of TNF-alpha-mediated cytotoxicity. Purified protein extracts possessed a marked ability to inhibit or neutralize the cytotoxic properties of TNF-alpha on the basis of survival of murine fibrosarcoma cell populations, compared with appropriate negative and positive reference controls. Relative purity of inhibitors and estimation of approximate molecular weight were established by conventional reducing and nonreducing sodium dodecyl sulfate. polyacrylamide gel electrophoresis analysis. Equine inhibitory protein fractions from mixed WBC populations, purified in the manner described, had molecular weights of 70,000 to 80,000 and 28,000. An analogous protein fraction of 28 kDa also was isolated from equine concentrated urine. Estimated isoelectric point of TNF-alpha inhibitor protein fractions was between pH of 5.5 and 6.1. These physical characteristics of equine TNF-alpha inhibitor protein fractions were similar to those described for a membrane-associated TNF-alpha receptor protein shed from chemotaxin- and calcium-ionophor-stimulated human WBC populations.

A murine IgM monoclonal antibody causing bacterial agglutination was used in an immunoaffinity procedure to purify a serotype 1-specific polysaccharide epitope from Pasteurella haemolytica. The P haemolytica serotype 1-specific antibody was precipitated from peritoneal ascitic fluid, dialyzed, and covalently attached to cyanogen bromide-activated Sepharose 4B beads. Retention of purified antibody activity and coupling efficiency were > 99% when evaluated by ELISA, agglutination testing, and protein determination. Potassium thiocyanate was selected as an eluant on the basis of reversible dissociation of bacterial agglutination and was titrated for the lowest effective concentration. Immunobead activity was observed microscopically by immobilization of encapsulated P haemolytica serotype 1 and its reversible dissociation after elution with 0.4M potassium thiocyanate. Specificity of immobilization was visualized, using P haemolytica serotypes 2 and 5, which were not bound, and by blocking serotype-1 binding with homologous capsular material. Saline-extractable capsular material from P haemolytica serotype 1 was used as an antigen source. After elution of the serotype 1-specific polysaccharide epitope, the product was dialyzed and analyzed, using chemical and immunologic methods. The immunoaffinity product contained no detectable protein and greater than half the original hexosamine content. Using defined monoclonal antibodies in ELISA, titration of the original capsular material and the immunoaffinity product revealed specific retention of lipopolysaccharide, a 10- to 30-kd polysaccharide antigen common to all P haemolytica and P multocida serotypes, and serotype 1-specific capsular polysaccharide, indicating possible epitope sharing among polysaccharide antigens of P haemolytica serotype 1.

C-reactive protein (CRP) was isolated from equine serum by use of calcium-dependent affinity chromatography conjugated pneumococcal C-polysaccharide, anion exchange chromatography, and gel filtration. It was identified as genuine CRP by its immunochemical cross-reactivity with anti-human CRP, its homology with human CRP in amino acid composition, and its pentameric structure as revealed by electron microscopy. Purified equine CRP had a molecular weight of approximately 118,000 and was composed of 5 identical, nonglycosylated and noncovalently associated subunits with molecular weight of approximately 23,000 each. Equine CRP migrated in the region between beta- and gamma-globulin by results of immunoelectrophoresis, and its isoelectric point was about 7.0. In horses, increased CRP concentration was associated with clinical pneumonitis, enteritis, and arthritis, compared with values obtained in clinically normal horses by use of single radial immunodiffusion method. After IM administration of turpentine oil or castration, serum CRP concentration increased to 6 times higher than baseline values. Results indicate that CRP may be an acute-phase reactant protein in horses.

Lipopolysaccharide (LPS) fractions were obtained from smooth cultures of Brucella abortus strains 2308 and S-19 by butanol extraction procedures. The LPS from the initial butanol extraction contained 10 to 15% protein and was reduced to less than 1% protein by treatment with proteinase K. The LPS fractions were identified and characterized on the basis of the chemical analysis, sodium dodecyl sulfate gel electrophoresis, cesium chloride gradients, electron microscopy, and gel immunodiffusion. Results indicated that the butanol procedure is a reliable method in the extraction of LPS from Brucella abortus cells. Proteinase K-treated LPS containing less than 1% protein from strain 2308 was used to vaccinate BALB/cByJ mice. Immune and protective criteria for vaccinated and nonvaccinated mice were increased immunoglobulin (IgG and IgM) titers in sera of prechallenge-exposed mice, reduced colony-forming units/spleen, and splenomegaly in post-challenge-exposed mice. Results indicated that proteinase K-treated LPS was immunuogenic as well as protective for mice.