The objective of this study was to evaluate the feasibility of anaerobic co-digestion of brown water (BW) [feces-without-urine] and food waste (FW) in decentralized, source-separation-based sanitation concept. An effort has been made to separate the yellow water (urine) and brown water from the source (using no-mix toilet) primarily to facilitate further treatment, resource recovery and utilization. Batch assay analytical results indicated that anaerobic co-digestion [BW+FW] showed higher methane yield (0.54–0.59L CH4/gVSadded) than BW or FW as a sole substrate. Anaerobic co-digestion was performed in the semi-continuously fed laboratory scale reactors viz. two-phase continuous stirred-tank reactor (CSTR) and single-stage sequencing-batch operational mode reactor (SeqBR). Initial 120d of operation shows that SeqBR performed better in terms of organic matter removal and maximum methane production. At steady-state, CODs, CODt, VS removals of 92.0±3.0, 76.7±5.1 and 75.7±6.6% were achieved for SeqBR at 16d HRT, respectively. This corresponds to an OLR of 2–3gCOD/Ld and methane yield of about 0.41L CH4/gVSadded. Good buffering capacity did not lead to accumulation of VFA, showing better process stability of SeqBR at higher loading rates. The positive findings show the great potential of applying anaerobic co-digestion of BW+FW for energy production and waste management. In addition, daily flush water consumption is reduced up to 80%. Decentralized, source-separation-based sanitation concept is expected to provide a practical solution for those countries experiencing rapid urbanization and water shortage issues, for instance Singapore.

Accurate measurement of water activity (aw) is an important goal for the food industry because aw is a key parameter in microbial growth, biological reaction rates and physical properties. An experimental device was setup using air-product water balance to non-destructively estimate the time-course of mean aw at the food product surface under well-controlled airflow conditions. The device is especially suited for studying the ripening of cheeses and fermented meat products, where water fluxes exchanged between products and air are very low. The validation tests performed with aw-known model products showed that water fluxes of 10(−7) kg s−1 can be estimated with an accuracy better than 2% over very short periods of time, and that surface aw can be estimated with an absolute uncertainty of less than 0.01 aw units. A handful of cheese ripening trials illustrate the potential of the method, highlighting the effects of a low air velocity and high air RH on the water exchanges occurring at a cheese surface, thus demonstrating the strong surface sensitivity to external air conditions.

The objective of this work was to study the microbial community and reactor performance for the anaerobic co-digestion of brown water and food waste in single- and two-phase continuously stirred tank reactors (CSTRs). Bacterial and archaeal communities were analyzed after 150days of reactor operation. As compared to single-phase CSTR, methane production in two-phase CSTR was found to be 23% higher. This was likely due to greater extent of solubilization and acidification observed in the latter. These findings could be attributed to the predominance of Firmicutes and greater bacterial diversity in two-phase CSTR, and the lack of Firmicutes in single-phase CSTR. Methanosaeta was predominant in both CSTRs and this correlated to low levels of acetate in their effluent. Insights gained from this study would enhance the understanding of microorganisms involved in co-digestion of brown water and food waste as well as the complex biochemical interactions promoting digester stability and performance.

In Kenya, 57% of the municipal solid waste generated is Food waste (FW) which has high organic content. However, the treatment and bioconversion of FW to biogas have always been challenging due to its rapid biodegradation, resulting from rapid hydrolysis and accumulation of volatile fatty acids and lowering pH in the bioreactor. In this study, the anaerobic digestibility of FW as a mono substrate was compared to co-digestion of FW with water hyacinth (WH) for improved biogas production and organic matter removal efficiency in a laboratory batch reactor. Different mix proportions of FW and WH were co-digested under mesophilic conditions (37 °C) at a dilution of 6% (w/v) Total Solids (TS) content. The TS of the substrates (Food waste and Water Hyacinth) were pre-processed to have a concentration of TS at 6% (60 g/L) to operate a wet AD which requires the substrate to be less than 15% TS. The proportions of WH: FW (v/v) were 100:0, 85:15, 70:30, 55:45, 30:70, 15:85, and 0:100. In the batch rectors the anaerobic co-digestion was conducted with Substrate to Inoculum (S/I) ratio of 1:1. FW is generally considered to have high volatile solids which hydrolyze rapidly lowering pH arising from excess production of Hydrogen which in presence of CO₂ and acetogenic bacteria leads to more production of acetate, formate and other long chain fatty acids which inhibits methanogenesis as a result of rapid acidification. The rapid acidification of the bioreactors that are used to treat FW results in the inhibition of the methanogenesis process. The co-digestion of the substrates could have improved the process parameters by reducing acidity caused by the high C/N ratio, reducing the inhibitory range, and increasing the buffer capacity which enhanced the bio-methane potential and the microbial activity. The batch experiments were set in triplicate for both cases of FW, WH, mixtures, and Inoculum. The results showed that the average gas yields after 81 days for the various mix proportions were 256.27and 357.69 ml/g-VS for mono-digestion of WH and FW respectively. For the mixtures of WH: FW the average reported biogas production were 305.01, 280.27, 548.91,616.01 and 270.87 ml/g-VS for mixtures of 15:85, 30:70, 55:45,70:30 and 85:15 respectively. The modified Gompertz model showed that the digesters with WH and FW alone had lag times of 2.599 and 1.052 days respectively. The mix substrates of WH: FW 85:15, 70:30, 55:45, 30:70 and 15:85 shown lag times of 2.456, 3.777, 2.574, 1.956 and 1.75 days respectively. A mix (WH: FW) of 70:30 had the highest maximum specific biogas production Rmax and the maximum biogas production potential of 18.19 mlCH₄/gVS per day and 607.7mlCH₄/gVS respectively. The R² and RSME values ranged from 0.9867 to 0.9963 and 2.663 to 9.359 respectively in all the digesters. The study shows that the co-digestion of WH and FW in the mix ratio of 70:30 improved the volume of biogas produced and organic matter removal efficiency reached 79%.